Assessments - 2, GPA: 3.5
(
)
)
|
Facilidade de uso
Improper installation and/or operation will void the warranty. ® WARNING If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a nearby phone. Follow the gas supplier's instructions. • If you cannot reach your gas supplier, call the fire department. Installation and service must be performed by a qualified installer, service agency, or gas supplier. AVERTISSEMENT Assurez-vous de bien suivres les instructions donnees dans cette notice pour reduire au minimum le risque d’incendie ou d’explosion ou pour eviter tout dommage materiel, toute blessure ou la mort. Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre appareil. QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ: • Ne pas tenter d’allumer d’appareils. • Ne touchez a aucun interrupteur. Ne pas vous servir des telephones dansle batiment ou vous vous trouvez. • Appelez immediatement votre fournisseur de gaz depuis un voisin. Suivez les instructions du fournisseur. • Si vous ne pouvez rejoindre le fournisseur de gaz, appelez le sservice des incendies. L’installation et l’entretien doivent etre assures par un installateur ou un service d’entretien qualifie ou par le fournisseur de gaz. IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS P/N 472643 Rev A - 05/22/06 SAVE THESE INSTRUCTIONS Page 2 Pentair Water Commercial Pool and Spa TABLE OF CONTENTS SECTION 1. General Information 1.1 Introduction...................................................3 1.2 Heater Identification ..................................... 3 1.3 Primary/Secondary Pump and Piping...........3 1.4 Certifications.................................................3 1.5 Engineering Assistance ................................ 3 SECTION 2. Installation 2.1 Boiler Placement .......................................... 4 2.2 Installation of Indoor Boilers ......................... 4 2.2.1 Combustion Air Supply ................................. 4 2.2.2 Venting ......................................................... 5 2.2.3 Common Venting System Test Procedure ............................................. 6 2.2.3 Instructions Relatives au Test des Systemes a Event Commun ......................... 6 2.3 Installation of Outdoor Boilers ...................... 7 2.4 Gas Supply and Piping ................................. 7 2.5 Electrical Wiring............................................8 2.6 General Piping Instructions .......................... 9 2.7 Boiler By-Pass Piping ................................... 9 2.8 Temperature Sensor Placement and Installation ............................................ 10 2.9 Automatic Chlorinators ............................... 10 SECTION 3. Operation 3.1 Controls - General ...................................... 11 3.2 Initial Start-Up ............................................. 11 3.3 Safety Shutoff Component Checkout ......... 12 3.4 Inlet Temperature and Temperature Rise Adjustment .................... 12 3.5 Heater Shut Down ...................................... 13 3.6 Spring and Fall Operation Stand-by Service ........................................ 13 3.7 Winter Operation Complete Shutdown ....... 14 3.8 Time Clock Operation.................................14 3.9 Therapeutic Pools (Spas) ........................... 14 SECTION 4. Maintenance..............................................15 SECTION 5. Troubleshooting .......................................16 SECTION 6. Parts Description and Order Numbers ................ 17 Pentair Technical Support Sanford, North Carolina (8 A.M. to 5 P.M.) Phone: (800) 831-7133 Fax: (919) 566-8920 Moorpark, California (8 A.M. to 5 P.M.) Phone: (800) 831-7133 Fax: (800) 284-4151 Web sites: visit and MegaTherm Commercial Pool Heating Boiler Page 3 SECTION 1. General Information 1.1 Introduction This manual provides information for the installation and operation of MegaTherm model MT pool heating boilers. It is strongly recommended that all application and installation procedures be reviewed completely before proceeding with the installation. Consult Pentair Commercial Pool and Spa, or your local sales representative, with any problems or questions regarding this equipment. Experience has shown that most problems are caused by improper installation, not system design. Some accessory items are shipped in separate packages. Verify receipt of all packages listed on the packing slip. Inspect everything for possible damage upon delivery, and inform the carrier of any shortages or impairments. Any such claims should be filed...