Assessments - 3, GPA: 4.7
(
)
)
|
Facilidade de uso
Follow the gas supplier’s instructions. If you cannot reach your gas supplier, call the fire department. 02/02 504,574M 2P0202 P504574M G60DF(X) Parts Identification BLOWER MOTOR DURALOKtmHEAT EXCHANGER ASSEMBLY CONTROL BOX CABINET FLUE COLLAR BLOWER ACCESS PANEL LOWER ACCESS PANEL BURNERS TWO-STAGE SURELIGHT™ INTEGRATED CONTROL BOARD COMBUSTION AIR INDUCER GAS MANIFOLD FIGURE 1 AWARNING Product contains fiberglass wool. Disturbing the insulation in this product during installation, maintenance, or repair will expose you to fiberglass wool. Breathing this may cause lung cancer. (Fiberglass wool is known to the State of California to cause cancer.) Fiberglass wool may also cause respiratory, skin, and eye irritation. To reduce exposure to this substance or for further information, consult material safety data sheets available from address shown below, or contact your supervisor. Lennox Industries Inc. P.O. Box 799900 Dallas, TX 75379-9900 NOTE - This manual must be left with the equipment user. A WARNING Do not set thermostat below 60°F (16°C) in heating mode. Setting thermostat below 60°F (16°C) reduces the number of heating cycles. Damage to the unit may occur that is not covered by the warranty. A WARNING If overheating occurs or if gas supply fails to shut off, shut off the manual gas valve to the appliance before shutting off electrical supply. A CAUTION Before attempting to perform any service or maintenance, turn the electrical power to unit OFF at the disconnect switch. Page 2 A WARNING Do not use this furnace if any part has been under water. Immediately call a qualified service technician to inspect the furnace and to replace any part of the control system and any gas control which has been underwater. A IMPORTANT Any additions, changes, or conversions required in order for the appliance to satisfactorily meet the application needs must be made by a Lennox service technician using factory specified and approved parts. A WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, personal injury or loss of life. Installation and service must be performed by a qualified installer, service agency orthe gas supplier. Important Directions 1 - Keep the furnace area clear and free of combustible material, gasoline, and other flammable vapors and liquids. If it is installed in an insulated area, the furnace must be kept free of insulating material. Insulating material may be combustible. 2 - DO NOT obstruct air flow to unit. Unit must receive an unobstructed flowofcombustion and ventilating air. 3 - DO NOT store chlorine orfluorine products near unit or introduce these products into the combustion air. These products can cause furnace corrosion. 4 - DO NOT draw return air from a room where this fur- nace, or any other gas appliance (ie., a water heater), is installed. When return air is drawn from a room, a negative pressure is created in the room. If a gas appliance is operating in a room with negative pressure, the flue products can be pulled back down the vent pipe and into the room. This reverse flow of the flue gas may result in incomplete combustion and the formation of carbon monoxide gas. This toxic gas might then be distributed throughout the house by the furnace duct system. A WARNING The blower door must be securely in place when the blower and burners are operating. Gas fumes, which could contain carbon monoxide, can be drawn into the living space resulting in personal injury or death. Your furnace is a gas appliance. It is critical that the gas supplied to the unit be completely burned to avoid the production ofcarbon monoxide gas. Complete combustion of the gas requires, but is not limited to, correct gas pressure and gas flow rate, adequate combustion air and proper venting. A WARNING Carbon monoxide gas is invisible, odorless, and toxic. Exposure to carbon monoxide gas can cause personal injury and even death to all occupants, including pets. Any item that is powered by, or gives off heat from, a combustion process (including lawn mowers, automobiles, and fireplaces) has the potential to produce carbon monoxide gas. Because of this, Lennox recommends the use of a carbon monoxide detector in your home, even if you do not own gas appliances. Reliable detectors are available at reasonable retail prices. Contact your Lennox dealer for more details about this investment in your safety. Your furnace is designed to meet standards set by national agencies. It should operate safely when properly installed and maintained. However, the unit's performance can be greatly impacted by the individual installation and the operating environment. It is your responsibility to ensure that this appliance is maintained. Proper maintenance is critical for your safety and the satisfactory operation of the product. Lennox strongly recommends annual inspection and maintenance of this appliance. Contact your Lennox d...