Assessments - 3, GPA: 4
(
)
)
|
Facilidade de uso
propane cylinder: dangerous -for emergency indoor home heating -for indoor use in commercial enclosures, This is an unvented having means for gas-fired heater. It uses providing combustion air (oxygen) from the air and ventilation, area in which it is used. such as construction Adequate combustion trailers or temporary and ventilation air must work enclosures. be provided. For recreational and commercial use WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. -Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. -An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. -Service must be performed by a qualified service agency What To Do If You Smell Gas: -Do Not try to light the appliance -Extinguish any open flames -Shut off gas to appliance Sales Office: 36 S. Franklin Street, Chagrin Falls. OH. 44022 PH.: (440) 247-0828 Operations Office: 12911 Taft Ave., Cleveland. OH. 44108 PH.: (216) 451-9300 DUE TO HIGH TEMPERATURES, THE HEATER SHOULD BE LOCATED OUT OF TRAFFIC AND AWAY FROM COMBUSTIBLE MATERIALS. Children and adults should be alerted to the hazard of high surface temperature and should stay away to avoid burns or clothing ignition. Young children should be carefully supervised when they are near the heater. Do not place clothing or other flammable material on or near the heater. Any safety screen or guard removed for servicing the heater must be replaced prior to operating the heater. The heater should be inspected before each use. Frequent cleaning may be required. The control compartments, burners and circulating air passageways of the heater must be kept clean. HEATER MAINTENANCE INSTRUCTIONS Do not obstruct the flow of combustion and ventilation air. Keep vent slots clean. Make a periodic visual check of pilot and burner flame to ensure proper operation. The pilot flame will extend beyond the thermocouple wrapping around it just under the tip. If yellow in color instead of blue, cleaning may be required. The burner should have a bright orange glow with a slight blue color around the border without any noticeable flame. A blue flame at the top of the ceramic tile is indicated excessive dust, dirt or spider webs inside the steel casing and/or reflector assembly, and means that cleaning is probably necessary. When cleaning heater (figure 1): 1. Disconnect disposable 1lb. cylinder (if using remote bulk tank turn off gas supply at remote cylinder valve, then disconnect hose from heater.) 2. Gently bend wire guard to remove wire guard prongs (a) from mounting holes in steel casing, freeing wire guard. 3. Insert a flat bladed screwdriver between the top (horizontal) edge of the reflector assembly (B) and the steel casing and push down until the steel tab (C) on the top edge of the reflector assembly releases from the steel casing. Gas-Fired Portable Unvented Heater for Recreational and Commercial Use Model No.: 7500 Input (BTU/hr.): 8000 Maximum, 4000 Minimum Gas Type: PropaneManifold Pressure: 11’’ W.C. 4. Ease reflector assembly away from steel casing. 5. Inspect casing interior components for spider webs as well as dust or dirt. a. If necessary use a vacuum cleaner or compressed air to clean: - Steel casing interior. -Burner orifice at orifice opening (D) -Pilot (E) through the holes in the pilot indicate by arrows in Figure 2. Never touch drilled holes in pilot, as they are extremely delicate. Insertion of pins, wire, etc. is likely to disturb proper gas flow. b. If necessary, use compressed air to clean venturi tube (F) and ceramic tile (G). 6. Ease reflector assembly back into steel casing. Pushing down on top edge with flat bladed screw driver, insert tab in hole in steel casing. 7. Gently bend wire guard and insert prongs into mounting holes in steel casing. Remember to check and clean the burner orifice and venturi tube on a regular basis to eliminate inserts, insect nests and spider webs. A clogged tube can lead to a fire. Keep Heater area clear and free from combustible materials, gasoline and other flammable vapors and liquids. Minimum Distance To Combustibles: Top 30’’, Front 24’’, Sides 6’’, Rear 0’’ Do not store or use gasoline or other flammable vaporsand liquids in the vicinity of this or any other appliance. INSTRUCTIONS FOR SAFE LIGHTING, OPERATION AND SHUTDOWN WHEN CONNECTING HEATER TO DISPOSABLE CYLINDER: INSTRUCTIONS FOR SAFE LIGHTING, OPERATION AND SHUTDOWN WHEN CONNECTING HEATER TO DISPOSABLE CYLINDER: Always connect the heater only to 16.4 oz. (1lb.) disposable propane cylinders that mate with a No. 600 Valve connection. The propane cylinder must be constructed and marked in accordance with the specifications for LP-gas cylinders of the U.S. Department of Transportation (DOT). Make certain Control Knob (Figure 4) is in OFF position. Screw 1 lb. disposable propane cylin...