Assessments - 4, GPA: 3.8
(
)
)
|
Facilidade de uso
Check valve stuck in open position. Replace check valve. DANGER—Do not disassemble the check valve with tank pressurized. Open tank petcock valve to allow air to escape from tank prior to servicing. Air leaks from safety relief valve: Possible defective safety relief valve. Operate safety relief valve manually by pulling on ring. If it still leaks, it should be replaced. Excessive tank pressure. Defective motor/pressure switch. Replace. Air leaks at pump: Blown gaskets. Replace blown gaskets and torque head bolts to 20 ft./lbs. CAUTION—Replace head gasket with a new one each time the head is removed to ensure proper sealing. Air leaks at fittings: Fittings are not tight enough. Tighten fittings where air can be heard escaping. Check fittings with soapy water solution. DO NOT OVERTIGHTEN. Air leaks in air tank: Defective or rusted air tank. Air tank must be replaced. DO NOT ATTEMPT TO REPAIR AIR TANK! Air blowing from inlet filter: Damaged inlet (reed) valve. Contact Consumer Helpline at 1-800-423-3598. Insufficient pressure at air tool or air accessory: Pressure regulator knob is not turned to high enough pressure. Adjust pressure regulator knob to proper setting. Defective motor/pressure regulator switch. Replace. Restricted air intake filter. Clean or replace the filter element. Air leaks. Check for leaks by applying soap solution to all fittings and connections. Bubbles will appear at leakage points. Tighen or replace leaking fittings or connections as needed. Hose or hose connections are too small or long. Replace with larger hose or connectors. Air compressor is not large enough for air requirement. Check the accessory air requirement. If it is higher than the CFM or pressure supply of the air compressor, you need a larger air compressor. Air compressor not making enough air: Restricted air intake filter. Clean or replace the filter element. Leaking (reed) valve. Drain air tank and measure pump up time. Compare to specifications. If lower, remove pump head and inspect valve plate, valve seats, and valve reeds. Clean or replace as needed. Restricted pilot valve. Clean or replace. Low compression. Low pressure may be due to worn piston rings and cylinder walls. Inspect for excessive wear and replace worn parts as needed. Excessive oil consumption: Restricted air intake filter. Clean or replace air filter element. Air compressor on unlevel surface. Do not incline the air compressor more than 10 degrees in any direction while running. Crankcase overfilled with oil. Drain oil. Refill to proper level with 30 weight non-detergent air compressor oil Plugged oil dipstick vent. Clean and check breather for proper ventilation. Oil leaks. Repair. Worn piston rings or scored cylinder. Replace worn or damaged parts as needed. Improper oil viscosity. Drain oil. Refill to proper level with 30 weight non-detergent air compressor oil. Oil has milky appearance: Water in oil due to condensation. Change oil and move air compressor to a less humid environment. Moisture in discharge air: Condensation in air tank caused by high level of atmospheric humidity or air compressor is not running long enough. Drain tank after every use. Drain air tank more often in humid weather and use an air line filter. PARTS LIST 15 NO. PART NO. DESCRIPTION QTY NO. PART NO. DESCRIPTION QTY 1 835534-1 Air Filter 1 55 835534-55 Bushing 2 2 835534-2 Connector 1 56 835534-56 Wheel 2 3 835534-3 Bolt M8x103 4 57 835534-57 Bolt M10 2 4 835534-4 Cylinder Head 1 58 835534-58 Foot 1 5 835534-5 Cylinder Head Gasket 1 59 835534-59 Nut 1 6 835534-6 Valve Plate 1 60 835534-60 Power Cord 1 7 835534-7 Valve Plate Gasket 1 61 835534-61 Pressure Switch 1 8 835534-8 Column 2 62 835534-62 Safety Valve 1 9 835534-9 Valve 1 63 835534-63 Pressure Gauge 2 10 835534-10 Cylinder 1 64 835534-64 Quick Coupler 1 11 835534-11 Cylinder Gasket 1 65 835534-65 Regulator Valve 1 12 835534-12 Piston Ring 3 66 835534-66 Internal Wire 1 13 835534-13 Piston 1 67 835534-67 Circuit Breaker 1 14 835534-14 Circlip 2 15 835534-15 Connecting Rod 1 16 835534-16 Crankcase 1 17 835534-17 Crank 1 18 835534-18 Bolt M8x30 1 19 835534-19 Rubber Gasket 1 20 835534-20 Breath Pipe 1 21 835534-21 Circlip 1 22 835534-22 Crankcase Cover 1 23 835534-23 Screw M5x14 6 24 835534-24 Oil Leveler 1 25 835534-25 Oil Leveler Gasket 1 26 835534-26 Bolt M12x1.5 1 27 835534-27 Bearing 6204 1 28 835534-28 Washer 1 29 835534-29 Capacitor 1 30 835534-30 Lock Washer 1 31 835534-31 Nut M8 1 32 835534-32 Piston Pin 2 33 835534-33 Fan Cover 1 34 835534-34 Screw M5x8 2 35 835534-35 Screw 2 36 835534-36 Circlip 1 37 835534-37 Fan 1 38 835534-38 Bolt M5x103 4 39 835534-39 Motor Cover 1 40 835534-40 Corrugated Washer 1 41 835534-41 Bearing 6202 1 42 835534-42 Stator 1 43 835534-43 Rotor 1 44 835534-44 Nut M8 4 45 835534-45 Check Valve 1 46 835534-46 Tubing 1 47 835534-47 Bolt M8x25 6 48 835534-48 Tubing 1 49 835534-49 Handle 1 50 835534-50 Tank 1 51 835534-51 Drain Valve 1 52 835534-52 Nut M10 2 53 835534-53 Spring 2 54 8355...